[Jewelry making - Article 00134] - Re: [Orchid] Noisy Foredom suggestions

[LEESSILVER]

========[ Invite a Friend - http://www.ganoksin.com/invite.htm  ]========

Connie,

    The starting problem could be worn brushes. You should  inspect them
    and replace them if the show lots of wear.  You can order  brushes
    from any one of the jewelry supply houses. 

    The noise problem could be due to several things. You might
    disconnect the cable assembly from the motor.  Then run the  motor. 
    If you still have the noise with the cable removed then the  noise
    is coming from the motor.  The noise could be the fault of  the bad
    bearings.  Foredom could replace the bearings. 

    If there is no noise when the cable is removed then the  problem is
    in the cable.  You can replace the entire cable assembly or 
    replaces pieces until the noise is gone. 

    To start with lube the existing shaft.  If that does not  end the
    noise you need to install a new shaft in the  sheath.  Lube it well
    before placing it in the sheath.  If you  still have noise after
    installing a new shaft then you will need to install a  new sheath. 

    All cable pieces, brushes and lube can be purchased from any one of 
    the jewelry supply houses. 

Lee Epperson

____________________________________________________________________
T h e   O r c h i d   L i s t
Open Electronic Forum for Jewelry Manufacturing Methods and Procedures
____________________________________________________________________
Orchid FAQ:
~ http://www.ganoksin.com/orchid/faq.htm
Orchid Archives:
~ http://www.ganoksin.com/orchid/archive
Orchid Galleries:
~ http://www.ganoksin.com/orchid/gallery.htm
Invite a Friend:
~ http://www.ganoksin.com/invite.htm
____________________________________________________________________
Tips From The Jeweler's Bench - Article Archive
~ http://www.ganoksin.com/borisat/tip_sear.htm
The Jeweler's Selected Bibliography List
~ http://www.ganoksin.com/jewelry-books
Buy Orchid Jewelry:
~ http://www.ganoksin.com/shop
____________________________________________________________________
-Unsubscribe:
-Email: orchid-request AT ganoksin.com Body=unsubscribe subject=blank
____________________________________________________________________